Product ID:C I MASTIC, FOSTER 60-26
MSDS Date:12/11/1988
FSC:8040
NIIN:00N020831
MSDS Number: BLKNV

H B FULLER CO

1200 WOLTERS BLVD
VADNAIS HEIGHTS, MN 55110
US

Emergency Phone: 612-481-3300

Info Phone: 612-481-3300

Preparer: INDUSTRIAL HYGIENE

Cage: 0HD19

H B FULLER CO

VADNAIS HEIGHTS, MN 55110 US

Telephone: 612-481-3300

Cage: 0HD19

ASPHALT (PETROLEUM)

CAS: 8052-42-4

RTECS: CI9900000

Fraction By Weight: 40-50%

ACGIH TLV: 5 MG/M3; (FUME);9192

STODDARD SOLVENT

CAS: 8052-41-3

RTECS: WJ8925000

Fraction By Weight: >10%

OSHA PEL 500 PPM

ACGIH TLV: 100 PPM; 9293

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES: CONTACT WITH PROD OR HIGH VAPOR
LEVELS WILL CAUSE MODERATE IRRIT. SKIN: LIQ CONTACT WILL DRY &
DEFAT SKIN. REPEATED OR PROLONGED CONTACT MAY CAUSE IRRIT & DERMAT.
EXPOS TO ASPHALT MAY INCREASE S ENSITIVITY TO SUNLIGHT. INHAL:
OVEREXP TO VAPS IN POORLY VENTILATED AREAS WILL CAUSE IRRIT OF THE
(SEE EFTS OF OVEREXP)
Effects of Overexposure:HLTH HAZ: NOSE, THROAT AND RESPIATORY TRACT AND
MAY CAUSE DIZZINESS, HEADACHES, NAUSEA OR UNCONSCIOUSNESS.
(CHRONIC) LONG TERM OVEREXPOS TO SOLV MAY CAUSE LIVER & KIDNEY DMG.
SKIN PAINTING STUDIES WIT H MICE HAVE SHOWN EVIDENCE OF SKIN
CANCER.PETROL. ASPHALT CONTAINS SMALL AMOUNT OF POLYAROMATIC
HYDROCARBONS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:EYES: FLUSH IMMEDIATELY WITH LARGE AMTS OF WATER FOR AT LEAST
15 MIN. CALL MD. SKIN: WASH AFFECTED AREA WITH SOAP & WATER.
LAUNDER CONTAMINATED CLTHG BEFORE REUSE. INHAL: REMOVE FROM
EXPOSURE. RESTORE BREATHING IF NECESSARY. KEEP WARM AND QUIET.
CALL MD. INGEST: CALL MD IMMEDIATELY .

Flash Point Method:SCC
Flash Point:108F,42C
Lower Limits:SEE INGR 2
Extinguishing Media:USE WATER SPRAY, FOAM, DRY CHEMICAL OR CO2.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:THERE IS THE POSSIBILITY OF PRESSURE
BUILDUP IN CLOSED CONTAINERS WHEN HEATED. WATER SPRAY MAY BE USED
TO COOL THE CONTAINERS.

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE
AREA. AVOID BREATHING VAPORS. DIKE AND CONTAIN SPILL WITH INERT
ABSORBENT AND TRANSFER TO CONTAINER FOR DISPOSAL. USE NON-SPARKING
TOOLS. KEEP SPILL OUT OF SE WERS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE IN COMPLIANCE WITH OSHA
1910.106. DO NOT STORE NEAR HEAT, SPARKS OR FLAME.
Other Precautions:DRUMS OF THIS MATL SHOULD BE GROUNDED WHEN POURING.
KEEP AWAY FROM HEAT, SPARKS & FLAME. AVOID BRTHG VAPS. USE ONLY
W/ADEQ VENT. AVOID CONT W/EYES, SKIN & CLTHG. KEEP CNTNR CLOSED.
EMPTIED CNTNR RETAI NS VAP & PROD RESIDUE. (SEE SUPP DATA)

Respiratory Protection:USE NIOSH/MSHA APPROVED EQUIPMENT - ORGANIC
VAPOR RESPIRATORS WHEN AIRBORNE EXPOSURE LIMITS ARE EXCEEDED.
Ventilation:LOCAL EXHAUST VENTILATION PREFERRED. PROVIDE VENTILATION TO
CONTROL CONTAMINANT LEVELS BELOW AIRBORNE EXPOSURE LIMITS.
Protective Gloves:RUBBER GLOVES.
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:PROTECTIVE CLOTHING. EYEWASH AVAILABLE WHERE
EYE CONTACT CAN OCCUR.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
WASTE DISP METH: REQUIREMENTS APPLY. FOR ADDITIONAL WASTE DISPOSAL
ASSISTANCE CONSULT H B FULLER ENVIRONMENTAL SERVICES 612/481-1588.
OTHER PREC: OBSERVE ALL LABELED SAFEGUARDS UNTIL CONTAINER IS CLEA
NED. DO NOT CUT OR WELD ON OR NEAR THISCONTAINER. LAUNDER
CONTAMINATED CLOTHING BEFORE REUSE.

HCC:F4
Boiling Pt:B.P. Text:>200F,>93C
Vapor Pres:SEE INGRED
Spec Gravity:1.1-1.2
Solubility in Water:NON-MISCIBLE
Appearance and Odor:LIQUID.

Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:INCOMPLETE COMBUSTION CAN YIELD LOW
MOLECULAR WEIGHT HYDROCARBONS, CO, NITROGEN COMPOUNDS.

Waste Disposal Methods:THIS PROD MEETS DEFINITION OF HAZ WASTE UNDER
U.S. EPA HAZ WASTE REGS 40 CFR 261. IT IS IGNITABLE WASTE CLASS
DOO1. DISPOSAL VIA INCINERATION IS REC. CONSULT YOUR FEDERAL,
STATE/LOCAL AUTHORITIES FOR PROPER DISP IN EVENT MORE RESTRICTIVE
(SUPP DATA)

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.